Home · Services · Broken Spring Replacement

Broken Spring Replacement in New Bedford, MA

Quick answer

Replacement of a broken torsion or extension spring, the part that actually lifts the door, matched to the door's weight and cycle rating.

Spring replacement is the January headline in New Bedford. Cold makes spring steel brittle at exactly the season when doors work hardest, and the state pattern, springs and cables failing in deep freezes, concentrates here on the coast where salt air has been thinning the coils all year. Springs are replaced in matched pairs, sized to the door's weight, and the cables are read at the same visit because the two fail as a system in this climate.

📞 Call PLACEHOLDER Request a callback

Signs you need broken spring replacement

A loud bang from the garage, then a door that will not open
A visible gap or separation in the coil spring above the door
The opener strains, hums, or lifts the door a few inches and stops
The door feels impossibly heavy when lifted by hand

What the job involves

1. Do not keep running the opener on a broken spring; it burns out the motor and can strip the gear, turning one repair into two.

2. The broken spring is measured (wire size, coil diameter, length) and the door is weighed, because the replacement must match the door, not the old spring's label alone.

3. Springs are replaced in pairs when both are the same age; the second spring has the same cycle count as the one that broke.

4. New springs are wound to spec and the door is balance tested: a balanced door stays halfway up when released.

5. Cables and end bearings are checked while the system is apart, since they wear on the same schedule.

What affects the price

Torsion versus extension system, and single versus double spring doors
Door weight and height (tall and insulated doors need heavier springs)
Cycle rating chosen: standard springs are rated around 10,000 cycles, high cycle options cost more and last longer
Whether the opener was damaged by running against the broken spring

When it is an emergency

A broken spring is a same day call when the car is trapped or the door is stuck open, and a do not use it call either way. Never try to wind or unwind a torsion spring with improvised tools: the spring holds enough stored energy to break bones, and this is the one job in the garage that injures DIYers every year.

📞 PLACEHOLDER

Broken Spring Replacement across the New Bedford area

Downtown New Bedford and the Whaling District North End and Acushnet Avenue South End West End Clarks Point Far North and the Airport Side

Related services

Garage Door Repair

Diagnosis and repair of a garage door that will not open, will not close, opens partway, or runs rough and loud.

Emergency Garage Door Service

Same day and after hours service for the doors that cannot wait: stuck open, stuck shut with a car inside, off track, or hanging crooked.

Garage Door Opener Repair

Troubleshooting and repair of a garage door opener that will not run, runs and reverses, or has lost its remotes, keypad, or safety sensors.

Garage Door Opener Installation

Replacement and installation of a new garage door opener, sized to the door, with modern safety sensors, remotes, and battery backup options.

Request a callback

Prefer to talk later? Leave your details and an independent local pro will call you back. No charge to you, no obligation.

Acushnet Garage Door Co is a free referral service. Submitting this form connects you with independent local contractors who provide the work.